Plumbing, Heating and Pool Repair Guides

Polaris Booster Pump Troubleshooting & Repair Guide

/
/
/
13168 Views

The Polaris booster pump is the driving engine for the Polaris pool cleaner. The booster pump provides a higher pressure then the swimming pool pump can so it can drive the Polaris cleaning unit. From time to time your booster pump will need some repairs or could have a problems that can only be diagnosed with some booster pump troubleshooting. Polaris Booster Pump Troubleshooting & Repair Guide

Some common things that go wrong with the Polaris booster pump are bad mechanical pump seals, overheated suction and discharge fittings and leaks from the Polaris quick connect fittings. All of these problems can be fixed with a few replacement parts that are available online or from your local swimming pool supply store that carries replacement Polaris booster pump parts.To avoid costly booster pump repairs you should always replace the small parts that are starting to show wear or damage right away. This means if you start to see your pump seal leaking, don’t wait until it gets so bad that you cannot run the pump.
Polaris Booster Pump

Soon as you see it leak replace it. This goes for anything else you see going bad on the pump. If you feel that something is going to break or looks like its damaged, you will want to shut the pump off right away and fix the problem. Ignoring or “putting off” the problem with the pump will only let the problem become worse and that will usually cost you more money and time to do the repairs.

How To Change The Polaris Booster Pump Seal

The Polaris booster pump seal is located inside of the seal housing. You will have to remove the front of the pump to first access the impeller. Once you have the front of the volute off you will want to now remove the impeller. In order to remove the impeller you will have to grab the back of the motor shaft and then with your other hand you will want to twist the impeller counter clockwise spinning it until it spins completely from the motor shaft.

Now that you have the impeller off you will want to unbolt the seal housing from the frame of the motor. Once you remove the seal housing you can remove the seal base. This is just one part of the mechanical pump seal. The second part of the Polaris booster pump seal will be in the small shaft of the impeller. You will also want to remove this part from the base of the impeller, as you will be replacing both parts of the booster pump mechanical seal.

Once you have removed both the pump seal seat and the spring from the impeller you can replace both parts for the new replacement Polaris pump seal that you have bought. It’s always a good idea to put a tad of silicon on the outer rubber casing of the seal seat. This will hold the seat in place inside the seal housing and also safeguard the seal base from leaking. After you insert the seal base you can slip the other part of the mechanical seal onto the impeller. Now you can turn the impeller clockwise and thread it back onto the pump shaft until it’s tight. Once the Polaris pump impeller is tight you can re-assemble the rest of the Polaris pump as the pump seal has now been changed.

How To Repair Suction Leaks On The Booster Pump

The Polaris booster pump could have some suction leaks in a few common places. The most common places that the booster pump will draw air from is the suction fitting and the volute drain plug. To avoid any air being sucked into the Polaris pump you will want to make sure that you Teflon tape both he threads on the suction fitting and the Polaris pump drain plug.

How To Hook Up The Polaris Booster Pump

The Polaris booster pump can be piped directly into your swimming pools filter system using PVC pipe or it can be installed with saddle clamps that can be connected to the existing swimming pool plumbing. Either way there is only one correct way to hook up the Polaris booster pump.

There is two fitting on the booster pump. The fitting in the front of the pump is called the suction fitting. This fitting will get connected to the discharge side of the swimming pool fitting. This is very important, as you will need to feed the suction side of the Polaris pump with pool water from the filter system. That is why you need to hook it to the discharge side of the pool system. The second fitting or the second connection you will make is to connect the discharge side of the Polaris booster pump to the line that returns back to the pool or to a flexible line that will go to the pool. Whether the Polaris is hooked to the wall fitting in the pool or if its being feed from a flexible like from the top of the discharge side it is important to remember that the Polaris 360, 390 or the Polaris black max are pressure driven units.

How To Turn On The Booster Pump

The booster pump will run if the pool pump is running. This is a safe guard to make sure that the proper amount of water flow is going through the booster pump. As we explained above the Polaris pump needs water from the discharge side of the swimming pool pump so when the Polaris pump is wired by the electricians it should be wired to only come on when the pool filter and pump are running.

To turn on the booster pump you will want to first turn on your swimming pool pump and let it come to full prime. Once the swimming pool pump has been running for a few minutes you can either turn the booster pump timer switch or on use the manual switch that will be located somewhere near the filter system or the timer control panel. Some pools will have both the manual Polaris override power switch and the Polaris timer and some will just have one or the other. Depending on who built your swimming pool will depend on how they wired your Polaris pool cleaning system.

How To Set The Booster Pump Timer

If you have a timer on your Polaris swimming pool cleaner you will want to set it to go on 30 minutes after your pool filter timer comes on. You will want to have the Polaris cleaner shut off about 45 minutes before the filter system does.

To set the timer on the Polaris you first will have to locate the time box. Once you locate the time box you will want to open the timer cover door and inside you will see a dial and two-timer pins. These timer pins will each have a small setscrew in them that you can loosen by hand. One time pin will say off and one timer pin will say on. If you turn the setscrews to the left, which is counter-clockwise you can loosen them and then slide them on the dial to the correct time. Once you have the off and the on pin set you can switch the timer on and if its between those times and the pool filter system is running your Polaris will start working.

Popular Polaris Pump Troubleshooting Questions:

Question: “Does my Polaris Pump filter my pool?”

Answer: No, The swimming pool filter system actually filters the pool but the Polaris unit will pick up and bag the debris inside of the pool.

Question: “Where can I get my Polaris Pump repaired?”

Answer: Most pump or motor repair shops can repair the Polaris pump.

If you have another Polaris Pump question please ask below:

189 Comments

  1. Hi Jim,

    You can see a parts list here at Pool Center:

    http://www.poolcenter.com/parts_pumps_polaris_halcyon_booster.htm

    These are the replacement parts available right now for that model.

    Kinda looks like you might have to buy a new motor as that plastic assembly is now attached to the motor. Seems Polaris changed the way they make there motors now,

    The regular PB4-60 has that plastic removable…….

    I hope this helps you, and let me know if you need any more help.

    Joseph

  2. Hi, I have had to replace my polaris booster pump electric motor 3 times because after about a season of use, there is a leak in the valute that runs back down the motor shaft and ruins the bearings. Aggreviating and expensive. Why does it continue to leak? Each time I have taken it apart to replace #3,#4 and #7 above, I find that the metal portion of #3 to be rusting. I put silicone on it each time. I have a salt water pool. More importantly, is it possible to change the bearings myself? I now have 2 motors in my garage that work fine except for the bearings. Please help! Thank you!

  3. Hi Joseph,
    When I turn on my booster pump I hear a humming noise that continues for a few seconds, then a click and the humming stops. If I turn the pump off and back on right away, nothing happens. If I wait a short time, I hear another click and then when I turn the switch back on it hums again but then clicks and then nothing. My local pool store diagnosed the problem (over the phone without actually seeing the pump or motor) as a bad motor and said I’d have to replace the motor. Then they remembered something and said I couldn’t replace just the motor, I’d have to replace the whole pump (I don’t know if that was because it couldn’t be done, or they just didn’t carry the motor separately). My main question is whether there might be some other test I can do to confirm that the motor is actually bad. If it is bad, I see several places where it appears I could buy just the motor online. Is replacing just the motor something that someone who’s about a medium on the “handiness chart” should attempt?
    Thanks.
    Keith

    • Hi Keith,

      What MODEL of the booster pump do you have?

      There are two styles, and the motor can bet replaced on both,

      It does sound like a bad motor or a jammed impeller.

      Does the motor shaft turn freely when the pump is off?

      Let me know the above and I can help further.

      Joseph

  4. Thanks Joseph.

    The label on the pump motor says PB-4 Booster Pump.
    The motor shaft seems to turn freely with the motor off.

    Keith

  5. Hi Joseph,

    I have a PB4-60 booster pump that seems to have gotten quite louder in recent weeks. It is hard piped with pvc(suction/inlet) and it runs a Polaris 280 cleaner. The cleaner doesn’t seem to be working as well as far as suction goes. I noticed that “Barry” wrote on June 27, 2009, about his booster being noisy too and you said that his motor bearing may have failed and you could explain how to repair it. Does this sound like the same issue as Barry is having with his Booster pump? How do you replace the bearing or is a new motor in order???

    Unsure,

    Paul

    • Hi Paul.

      Yes, you will need to change the motor bearings or have them replaced. I am currently working on an article to explain how to do so for you and Barry.

      I will update this comment area and provide the link to the article in the next 24 – 48 hours.

      Joseph

  6. Wet Head Media replied to Barry’s problem of a loud humming noise while the booster pump is running “that usually means you need to change the motor bearing.” I purchased a new booster pump when a local pool repair company told me that changing the motor bearing and replacing the seals and O rings was more expensive than buying a replacement pump. I still have the old motor and pump. I would be interested in instructions for changing the bearings so that I could have a replacement pump on hand. These things always seem to break down during a four day holiday weekend.

    • Hi DrMac.

      I understand what the “Pool Companies” have told you, and that generally is because they have no idea how to build a pump, In fact replacement bearings are generally under $20 for both the front bearing and the rear.

      You will off course needs some basic and specialty hand tools and off course need to be “Handy” but if that sounds like you, Then you CAN save a bunch of money.

      I will be posting a “How To Change Polaris Pump Motor Bearings” within 12 hours and I will post the link here.

      Let me know if you need more help,

      Joseph

  7. Hi Joseph,

    I suspect you missed my earlier reply to your questions about my non-working booster pump of a couple days ago so am trying again…

    You asked about the model of my booster pump. The label on the pump motor says PB-4 Booster Pump. The motor is an AO Smith and is marked B625.

    You also asked if the motor shaft turned freely with the motor off. It does. I assume that means that it’s likely a bad motor.

    When I turn on the pump, the motor hums for a few seconds and then clicks off. Is my next step to try to replace the motor or is there something else I can try?

    Keith

    • Hi Keith,

      Sorry about that, sometimes I loose track. Before I say “bad motor”.

      Does your motor look like this?

      Does it have a Capacitor on the motor, because I have seen the Polaris pump with this style (been replaced / etc ) and if so you could just have a bad Capacitor , But that is if you have this style motor.

      Let me know,

      Joseph

  8. Phillip,
    Water is not running through our booster pump. We have re-primed the main pump and still nothing.
    What could be wrong?

  9. Becky,

    If there is power, Then there has to be a “restriction” meaning a “closed valve”

    Most Polaris have a valve either in front or somewhere on the system,

    Would it be possible for you to take a picture of your filter system and then post it here?

    Let me know,

    Joseph

Leave a Comment

Your email address will not be published.

This div height required for enabling the sticky sidebar
Ad Clicks : Ad Views : Ad Clicks : Ad Views : Ad Clicks : Ad Views : Ad Clicks : Ad Views : Ad Clicks : Ad Views : Ad Clicks : Ad Views :