Plumbing, Heating and Pool Repair Guides

Polaris Booster Pump Troubleshooting & Repair Guide

/
/
/
12739 Views

The Polaris booster pump is the driving engine for the Polaris pool cleaner. The booster pump provides a higher pressure then the swimming pool pump can so it can drive the Polaris cleaning unit. From time to time your booster pump will need some repairs or could have a problems that can only be diagnosed with some booster pump troubleshooting. Polaris Booster Pump Troubleshooting & Repair Guide

Some common things that go wrong with the Polaris booster pump are bad mechanical pump seals, overheated suction and discharge fittings and leaks from the Polaris quick connect fittings. All of these problems can be fixed with a few replacement parts that are available online or from your local swimming pool supply store that carries replacement Polaris booster pump parts.To avoid costly booster pump repairs you should always replace the small parts that are starting to show wear or damage right away. This means if you start to see your pump seal leaking, don’t wait until it gets so bad that you cannot run the pump.
Polaris Booster Pump

Soon as you see it leak replace it. This goes for anything else you see going bad on the pump. If you feel that something is going to break or looks like its damaged, you will want to shut the pump off right away and fix the problem. Ignoring or “putting off” the problem with the pump will only let the problem become worse and that will usually cost you more money and time to do the repairs.

How To Change The Polaris Booster Pump Seal

The Polaris booster pump seal is located inside of the seal housing. You will have to remove the front of the pump to first access the impeller. Once you have the front of the volute off you will want to now remove the impeller. In order to remove the impeller you will have to grab the back of the motor shaft and then with your other hand you will want to twist the impeller counter clockwise spinning it until it spins completely from the motor shaft.

Now that you have the impeller off you will want to unbolt the seal housing from the frame of the motor. Once you remove the seal housing you can remove the seal base. This is just one part of the mechanical pump seal. The second part of the Polaris booster pump seal will be in the small shaft of the impeller. You will also want to remove this part from the base of the impeller, as you will be replacing both parts of the booster pump mechanical seal.

Once you have removed both the pump seal seat and the spring from the impeller you can replace both parts for the new replacement Polaris pump seal that you have bought. It’s always a good idea to put a tad of silicon on the outer rubber casing of the seal seat. This will hold the seat in place inside the seal housing and also safeguard the seal base from leaking. After you insert the seal base you can slip the other part of the mechanical seal onto the impeller. Now you can turn the impeller clockwise and thread it back onto the pump shaft until it’s tight. Once the Polaris pump impeller is tight you can re-assemble the rest of the Polaris pump as the pump seal has now been changed.

How To Repair Suction Leaks On The Booster Pump

The Polaris booster pump could have some suction leaks in a few common places. The most common places that the booster pump will draw air from is the suction fitting and the volute drain plug. To avoid any air being sucked into the Polaris pump you will want to make sure that you Teflon tape both he threads on the suction fitting and the Polaris pump drain plug.

How To Hook Up The Polaris Booster Pump

The Polaris booster pump can be piped directly into your swimming pools filter system using PVC pipe or it can be installed with saddle clamps that can be connected to the existing swimming pool plumbing. Either way there is only one correct way to hook up the Polaris booster pump.

There is two fitting on the booster pump. The fitting in the front of the pump is called the suction fitting. This fitting will get connected to the discharge side of the swimming pool fitting. This is very important, as you will need to feed the suction side of the Polaris pump with pool water from the filter system. That is why you need to hook it to the discharge side of the pool system. The second fitting or the second connection you will make is to connect the discharge side of the Polaris booster pump to the line that returns back to the pool or to a flexible line that will go to the pool. Whether the Polaris is hooked to the wall fitting in the pool or if its being feed from a flexible like from the top of the discharge side it is important to remember that the Polaris 360, 390 or the Polaris black max are pressure driven units.

How To Turn On The Booster Pump

The booster pump will run if the pool pump is running. This is a safe guard to make sure that the proper amount of water flow is going through the booster pump. As we explained above the Polaris pump needs water from the discharge side of the swimming pool pump so when the Polaris pump is wired by the electricians it should be wired to only come on when the pool filter and pump are running.

To turn on the booster pump you will want to first turn on your swimming pool pump and let it come to full prime. Once the swimming pool pump has been running for a few minutes you can either turn the booster pump timer switch or on use the manual switch that will be located somewhere near the filter system or the timer control panel. Some pools will have both the manual Polaris override power switch and the Polaris timer and some will just have one or the other. Depending on who built your swimming pool will depend on how they wired your Polaris pool cleaning system.

How To Set The Booster Pump Timer

If you have a timer on your Polaris swimming pool cleaner you will want to set it to go on 30 minutes after your pool filter timer comes on. You will want to have the Polaris cleaner shut off about 45 minutes before the filter system does.

To set the timer on the Polaris you first will have to locate the time box. Once you locate the time box you will want to open the timer cover door and inside you will see a dial and two-timer pins. These timer pins will each have a small setscrew in them that you can loosen by hand. One time pin will say off and one timer pin will say on. If you turn the setscrews to the left, which is counter-clockwise you can loosen them and then slide them on the dial to the correct time. Once you have the off and the on pin set you can switch the timer on and if its between those times and the pool filter system is running your Polaris will start working.

Popular Polaris Pump Troubleshooting Questions:

Question: “Does my Polaris Pump filter my pool?”

Answer: No, The swimming pool filter system actually filters the pool but the Polaris unit will pick up and bag the debris inside of the pool.

Question: “Where can I get my Polaris Pump repaired?”

Answer: Most pump or motor repair shops can repair the Polaris pump.

If you have another Polaris Pump question please ask below:

189 Comments

  1. I just installed a replacement Polaris Halcyon booster pump (PB4-60Q). The motor turns on for a few seconds but doesn’t seem to pump any water. The motor then shuts off. It will turn on again with the same result. I immediately turn off for fear of burning out the motor. Water is definitely circulating through the pump. Could this be a wiring problem? I have high voltage and wired my two hot wires (both red) to the yellow connectors inside the pump. The third wire was a simple ground attachment. Could the impeller by stuck?

    • I’m having the same problem with my pump. I am in the process of taking it apart. I think it may be the bearings in the motor but not sure.

  2. my old polaris vac sweep serial k89 fell off its base and has not worked since. the propeller disc now rotates anticlock wise. is this the right direction? if not , how do i fix it.

    thanks

  3. Hi There! Please help! I have a leak and I believe it has something to do with the booster pumb. I removed my polaris out of the pool and when I turn the pool on DE comes out where the polaris connects. Any ideas? And yes, the polaris suction was lower than usual.

    • Sounds like you have 2 problems. First, your DE filter is blowing through. This happened to me earlier this year. You need to take apart the filter and clean the filter grids. As to the Polaris suction, not sure. It is not related to your DE blow-thru problem. Fix the 1st one and then assess.

  4. my pb4 model # 152-3 was working fine 2 days ago, i turned it on today and nothing :( have manually switched it on and off but seems like no power going to it. i took off the starter on top but its all encased, wire connections look fine what could it be? please help unemployed and cant afford another one

  5. Hello. We just replaced our Polaris Booster Pump. It worked great for about a day. The cleaner came on, the timer worked perfectly,etc. But this afternoon we went out and tried to turn the cleaner on manually using our control panel. The booster pump does not come on at all. Any idea why this would be happening? Thanks.

  6. I replaced my Poloris PB4 last week. Other than the clips, it was pretty easy and the pump ran quiet and smooth & the poloris seemed to run well. A couple days later I found water squirting out the bottom. Is this just a simple seal leak on a new pump? Did I install part of it wrong? btw, other than showing the clips, the installation instructions seem to lack complete information.

  7. I just replaced my booster pump because it had burned out. I now have no water flow TO the booster pump. Am I supposed to prime the booster somehow? I was expecting that with the main motor running for a few (15mins) I would have flow on the intake side of the booster pump. Any thoughts on how to troubleshoot this?

    • Mike, I am experiencing the same ‘Primer’ problem. Did you ever get any helpful information ? Thank you >>>>

      • Arthur Barone,
        I had one of my jandy valves on the return side set to spa, so it wasn’t lettining water go to the aux. pump. Once I opened the valve everything worked.

        • Mike, Thank you very much for your reply. Just one more thing if I may, … I now have ‘water flow’, however the pump turns off after about 30 seconds (without tripping the breaker), and then starts up a minute later, in a seemingly endless cycle. In all that I have read, it is a Primer problem, but I have verified that no air is in the pump by loosening the drain plug while operating, as well as independently releasing each end of the flex hose located at the top of the pump, and the dedicated return to the pool. Water flow (sans air) was confirmed each time. Is there something I am missing ? Another post indicated the same problem, but the recommended solution was removing the ‘small plug’ at the top of the unit and filling with water. My PB4-60 has no ‘small plug’ at the top, and as I stated the unit is full w/water to capacity. As always, thank you in advance for your time, effort and insight ! Regards … AB

  8. I currently have a Polaris PB4 pump system running my cleaner. It has stopped pumping for some reason. Can I remove this pump from the motor and will the Polaris P5 booster pump bolt right up without any modifications?

  9. With new variable speed filter pump I need to know what the minimum flow rate is for input to the booster pump.

  10. What is the recommended solution if the impeller does not spin when the power is turned on the the booster pump (Polaris PB4). I took the front off and manually turned it with a bit of difficulty. I have been successful doing this the 2 years prior. Do I need to replace parts and buy a kit? Is it possible to lubricate? I did not have any leaks last year.

  11. My polaris pump is not running. When it switches on I am getting a humming noise but the pump is not running. Any suggestions.

  12. My Polaris used to swim around and clean the pool like crazy. Over the last two years it has really slowed down and the pressure to the Polaris is really reduced. I have a PB4 pump. I need a diagnosis. Has anyone had this problem? New seals perhaps?

Leave a Comment

Your email address will not be published.

This div height required for enabling the sticky sidebar
Ad Clicks : Ad Views : Ad Clicks : Ad Views : Ad Clicks : Ad Views : Ad Clicks : Ad Views : Ad Clicks : Ad Views : Ad Clicks : Ad Views :